Conversion of carbon dioxide in biogas into acetic acid by Clostridium thailandense immobilized on porous support materials.

This study aimed to convert CO2 in biogas into acetic acid using immobilized Clostridium thailandense cells on various support materials, including activated carbon, expanded clay, and coir. Immobilized cells and free cells were evaluated for their CO2 conversion ability into acetic acid using H2 as an electron donor at an H2 to CO2 in biogas ratio of 2:1 (v/v), 30 °C, 150 rpm. Results showed that immobilized cells on activated carbon increased CH4 content to 96.9% (v/v), and acetic acid production to 15.65 mmol/L within 96 h. These values outperformed free cells. The activated carbon-immobilized cells could be reused two times without losing efficacy in the purification of biogas and acetic acid production. This work indicates that using the immobilized cells offers a sustainable approach to biogas upgrading, reducing the environmental footprint of biogas production by increasing its energy content and purity.

Enhancing bio-hydrogen and bio-methane production of concentrated latex wastewater (CLW) by Co-digesting with palm oil mill effluent (POME): Batch and continuous performance test and ADM-1 modeling.

This study aimed at investigating the biohydrogen and biomethane potential of co-digestion from palm oil mill effluent (POME) and concentrated latex wastewater (CLW) in a two-stage anaerobic digestion (AD) process under thermophilic (55 ± 3 °C) and at an ambient temperature (30 ± 3 °C) conditions, respectively. The batch experiments of POME:CLW mixing ratios of 100:0, 70:30, 50:50, 30:70, and 0:100 was investigated with the initial loadings at 10 g-VS/L. The highest hydrogen yield of 115.57 mLH2/g-VS was obtained from the POME: CLW mixing ratio of 100:0 with 29.0 of C/N ratio. While, the highest subsequent methane production yield of 558.01 mLCH4/g-VS was achieved from hydrogen effluent from POME:CLW mixing ratio of 70:30 0 with 21.8 of C/N ratio. This mixing ratio revealed the highest synergisms of about 9.21% and received maximum total energy of 19.70 kJ/g-VS. Additionally, continuous hydrogen and methane production were subsequently performed in a series of continuous stirred tank reactor (CSTR) and up-flow anaerobic sludge blanket reactor (UASB) to treat the co-substate. The results indicated that the highest hydrogen yield of POME:CLW mixing ratio at 70:30 of 95.45 mL-H2/g-VS was generated at 7-day HRT, while methane production was obtained from HRT 15 days with a yield of 204.52 mL-CH4/g-VS. Thus, the study indicated that biogas production yield of CLW could be enhanced by co-digesting with POME. In addition, the two-stage AD model under anaerobic digestion model no. 1 (ADM-1) framework was established, 9.10% and 2.43% of error fitting of hydrogen and methane gas between model simulation data and experimental data were found. Hence, this research work presents a novel approach for optimization and feasibility for co-digestion of POME with CLW to generate mixed gaseous biofuel potentially.

Taxonomic and enzymatic basis of the cellulolytic microbial consortium KKU-MC1 and its application in enhancing biomethane production.

Lignocellulosic biomass is a promising substrate for biogas production. However, its recalcitrant structure limits conversion efficiency. This study aims to design a microbial consortium (MC) capable of producing the cellulolytic enzyme and exploring the taxonomic and genetic aspects of lignocellulose degradation. A diverse range of lignocellulolytic bacteria and degrading enzymes from various habitats were enriched for a known KKU-MC1. The KKU-MC1 was found to be abundant in Bacteroidetes (51%), Proteobacteria (29%), Firmicutes (10%), and other phyla (8% unknown, 0.4% unclassified, 0.6% archaea, and the remaining 1% other bacteria with low predominance). Carbohydrate-active enzyme (CAZyme) annotation revealed that the genera Bacteroides, Ruminiclostridium, Enterococcus, and Parabacteroides encoded a diverse set of cellulose and hemicellulose degradation enzymes. Furthermore, the gene families associated with lignin deconstruction were more abundant in the Pseudomonas genera. Subsequently, the effects of MC on methane production from various biomasses were studied in two ways: bioaugmentation and pre-hydrolysis. Methane yield (MY) of pre-hydrolysis cassava bagasse (CB), Napier grass (NG), and sugarcane bagasse (SB) with KKU-MC1 for 5 days improved by 38-56% compared to non-prehydrolysis substrates, while MY of prehydrolysed filter cake (FC) for 15 days improved by 56% compared to raw FC. The MY of CB, NG, and SB (at 4% initial volatile solid concentration (IVC)) with KKU-MC1 augmentation improved by 29-42% compared to the non-augmentation treatment. FC (1% IVC) had 17% higher MY than the non-augmentation treatment. These findings demonstrated that KKU-MC1 released the cellulolytic enzyme capable of decomposing various lignocellulosic biomasses, resulting in increased biogas production.

Efficient removal of tannins from anaerobically-treated palm oil mill effluent using protein-tannin complexation in conjunction with electrocoagulation.

Despite the significant removal of chemical oxygen demand (COD) by anaerobic digestion, anaerobically-treated palm oil mill effluent (POME) still contains tannins and other phenolic compounds, resulting in residual COD and a brownish color. In this study, we investigated the removal of tannins from anaerobically treated POME using protein-tannin complexation in conjunction with electrocoagulation. The amino acid composition of the protein, aqueous pH, and protein: tannin ratios were found to be important parameters affecting the tannin removal efficiency. Pig blood protein was superior to casein protein in removing tannins, possibly because it had aspartic acid as the major amino acid component. At an optimal condition with a pig blood protein: tannin ratio of 0.33 (w/w), a current density of 30 mA/cm2, pH 5, and an electrolysis time of 10 min, the removals of tannins, COD, and color were 93%, 96%, and 97%, respectively.

Deploying two-stage anaerobic process to co-digest greasy sludge and waste activated sludge for effective waste treatment and biogas recovery.

High-strength waste activated sludge (WAS) and greasy sludge (GS) were largely generated from canned tuna processing. This study reports the performance of the two-stage anaerobic process for co-digesting WAS and GS. Various WAS:GS mixing ratios of 0:100, 10:90, 20:80, 30:70, 40:60, 50:50, 60:40, 70:30, 80:20, 90:10, and 100:00 (volatile solids (VS) basis) were investigated in batch acidogenic stage at ambient (30 °C ± 3 °C), 55 °C, and 60 °C temperatures. Subsequently, the effluents from the first stage were used to produce methane in the second methanogenic stage at an ambient temperature. The highest methane yield of 609 mL CH4/g-VSadded was achieved using acidogenic effluents generated from a WAS:GS mixing ratio of 40:60 at an ambient temperature. The first-order kinetic constants (k) for the first (k1) and second (k2) stages were subsequently estimated to be 0.457 d-1 and 0.139 d-1, respectively. The obtained k constants were further used to predict the hydraulic retention time (HRT) for the two continuously stirred tank reactors (CSTR) in series. Consequently, the calculated 4-day HRT and 20-day HRT for 50-L CSTR1 and 250-L CSTR2, respectively, were used to operate the continuous two-stage process at an ambient temperature by feeding with a 40:60-WAS:GS mixing ratio. A satisfactory methane yield of 470-mL CH4/g-VS along with 75% chemical oxygen demand (COD) removal was generated. Furthermore, the predicted methane yield of 450-mL CH4/g-VS obtained from the simple kinetic CSTR model resembled the experimental yield with 96% accuracy. The obtained experimental results demonstrate that WAS and GS co-digestion could be successfully accomplished using a practical two-stage anaerobic process operated at an ambient temperature.

Performance of pilot scale two-stage anaerobic co-digestion of waste activated sludge and greasy sludge under uncontrolled mesophilic temperature.

Waste-activated sludge (WAS) and greasy sludge (GS) discharged from the canned tuna industry are considerably characterized as harsh organic wastes to be individually treated by using traditional anaerobic digestion. This study was attempted to anaerobically co-digest WAS and GS in continuous pilot scale two-stage process, comprising the first 50 L continuous stir tank reactor (CSTR1) and the second 250 L continuous stir tank reactor (CSTR2). The two-stage co-digesting operation of dewatered WAS:GS ratio of 0.4:1 (g-VS) at ambient temperature with the organic loading rate (OLR) of 12.6 ± 0.75 g-VS/L·d and 2.26 ± 0.13 g-VS/L·d, corresponding to 3-day and 17-day hydraulic retention time (HRT) for the first and second stage, respectively generated highest methane production rate of 957 ± 86 mL-CH4/L·d, corresponding to methane yield of 423.4 ± 36 mL-CH4/g-VS. Organic removal efficiency obtained was around 67.5% on COD basis. The microbial diversity was depended on the process's activity. Bacteria were mostly detected in the CSTR1, dominating with the phylum Firmicutes and Proteobacteria, whereas genus Methanosaeta archaea were found dominantly in the CSTR2. The economic analysis of process shows payback period (PBP), internal rate of return (IRR), and net present value (NPV) of 3 years, 30%, and 250,177 USD, respectively. This study demonstrated the potential approach to applying the two-stage anaerobic co-digestion process to stabilize both WAS and GS along with generating valuable bioenergy carriers.

Clostridium thailandense sp. nov., a novel CO2-reducing acetogenic bacterium isolated from peatland soil.

Some species of the genus Clostridium are efficient acetate producers and have been deemed useful for upgrading industrial biogas. An acetogenic, strictly anaerobic, Gram-stain-positive, subterminal endospore-forming bacterium designated strain PL3T was isolated from peatland soil enrichments with H2 and CO2. Cells of strain PL3T were 0.8-1.0×4.0-10.0 µm in size and rod-shaped. Growth of strain PL3T occurred at pH 6.0-7.5 (optimum, pH 7.0), at 20-40 °C (optimum, 30 °C) and with 0-1.5 % (w/v) NaCl (optimum, 0.5%). Biochemical analyses revealed that strain PL3T metabolized lactose, maltose, raffinose, rhamnose, lactic acid, sorbitol, arabinose and glycerol. Acetic acid was the predominant metabolite under anaerobic respiration with H2/CO2. The major cellular fatty acids were C16 : 0, C16 : 1 cis 9 and C17 : 0 cyc. The main polar lipids were diphosphatidylglycerol, phosphatidylethanolamine, aminolipid and aminophospholipid. Phylogenetic analysis based on 16S rRNA gene sequences showed that strain PL3T belongs to the genus Clostridium with the highest sequence similarity to Clostridium aciditolerans DSM 17425T (98.6 %) followed by Clostridium nitrophenolicum (97.8 %). The genomic DNA G+C content of strain PL3T was 31.1 mol%.The genomic in silico DNA-DNA hybridization value between strain PL3T and C. aciditolerans DSM 17425T was 25.1 %, with an average nucleotide identity of 80.2 %. Based on phenotypic, chemotaxonomic and phylogenetic differences, strain PL3T was suggested to represent a novel species of the genus Clostridium, for which the name Clostridium thailandense sp. nov. is proposed. The type strain is PL3T (=DSM 111812T=TISTR 2984T).

Strategies for recovery of imbalanced full-scale biogas reactor feeding with palm oil mill effluent.

BACKGROUND: Full-scale biogas production from palm oil mill effluent (POME) was inhibited by low pH and highly volatile fatty acid (VFA) accumulation. Three strategies were investigated for recovering the anaerobic digestion (AD) imbalance on biogas production, namely the dilution method (tap water vs. biogas effluent), pH adjustment method (NaOH, NaHCO3, Ca(OH)2, oil palm ash), and bioaugmentation (active methane-producing sludge) method. The highly economical and feasible method was selected and validated in a full-scale application. RESULTS: The inhibited sludge from a full-scale biogas reactor could be recovered within 30-36 days by employing various strategies. Dilution of the inhibited sludge with biogas effluent at a ratio of 8:2, pH adjustment with 0.14% w/v NaOH, and 8.0% w/v oil palm ash were considered to be more economically feasible than other strategies tested (dilution with tap water, or pH adjustment with 0.50% w/v Ca(OH)2, or 1.25% NaHCO3 and bioaugmentation) with a recovery time of 30-36 days. The recovered biogas reactor exhibited a 35-83% higher methane yield than self-recovery, with a significantly increased hydrolysis constant (kH) and specific methanogenic activity (SMA). The population of Clostridium sp., Bacillus sp., and Methanosarcina sp. increased in the recovered sludge. The imbalanced full-scale hybrid cover lagoon reactor was recovered within 15 days by dilution with biogas effluent at a ratio of 8:2 and a better result than the lab-scale test (36 days). CONCLUSION: Dilution of the inhibited sludge with biogas effluent could recover the imbalance of the full-scale POME-biogas reactor with economically feasible and high biogas production performance.

Improvement of empty palm fruit bunches biodegradability and biogas production by integrating the straw mushroom cultivation as a pretreatment in the solid-state anaerobic digestion.

Empty fruit bunches (EFB) have low biodegradability and restrict their commercial utilization in biogas plants. Integration of straw mushroom (Volvariella volvacea) cultivation as a function of bio-pretreatment on EFB to improve biodegradability and methane production by solid-state anaerobic digestion (SS-AD) was investigated. The mushroom yield was 47.3 kg·tonne-1 EFB with remaining weight in spent mushroom-EFB (S-mEFB) of 82%. The cellulose, hemicellulose, and lignin of EFB were degraded by 3.3%, 21.3%, and 17.6%, respectively, with an increased surface area of S-mEFB. The biodegradability of S-mEFB (62.7%) was 2 times higher than raw EFB (33.5%) with the highest methane yield and production of 281 mL CH4·g-1 VS and 50.6 m3·tonne-1 S-mEFB, respectively. The co-digestion of S-mEFB with 5% v/w POME had highest methane yield of 405 mL CH4·g-1 VS with biodegradability of 90.8%. Integrating straw mushroom cultivation with SS-AD is a promising strategy for achieving an environmentally friendly and economically feasible process.

Comparative assessment of single-stage and two-stage anaerobic digestion for biogas production from high moisture municipal solid waste.

BACKGROUND: Anaerobic digestion (AD) is a suitable process for treating high moisture MSW with biogas and biofertilizer production. However, the low stability of AD performance and low methane production results from high moisture MSW due to the fast acidify of carbohydrate fermentation. The effects of organic loading and incineration fly ash addition as a pH adjustment on methane production from high moisture MSW in the single-stage AD and two-stage AD processes were investigated. RESULTS: Suitable initial organic loading of the single-stage AD process was 17 gVS L-1 at incineration fly ash (IFA) addition of 0.5% with methane yield of 287 mL CH4 g-1 VS. Suitable initial organic loading of the two-stage AD process was 43 gVS L-1 at IFA addition of 1% with hydrogen and methane yield of 47.4 ml H2 g-1 VS and 363 mL CH4 g-1 VS, respectively. The highest hydrogen and methane production of 8.7 m3 H2 ton-1 of high moisture MSW and 66.6 m3 CH4 ton-1 of high moisture MSW was achieved at organic loading of 43 gVS L-1 at IFA addition of 1% by two-stage AD process. Biogas production by the two-stage AD process enabled 18.5% higher energy recovery than single-stage AD. The 1% addition of IFA into high moisture MSW was useful for controlling pH of the two-stage AD process with enhanced biogas production between 87-92% when compared to without IFA addition. Electricity production and energy recovery from MSW using the coupled incineration with biogas production by two-stage AD process were 9,874 MJ ton-1 MSW and 89%, respectively. CONCLUSIONS: The two-stage AD process with IFA addition for pH adjustment could improve biogas production from high moisture MSW, as well as reduce lag phase and enhance biodegradability efficiency. The coupled incineration process with biogas production using the two-stage AD process was suitable for the management of MSW with low area requirement, low greenhouse gas emissions, and high energy recovery.

Hydrochar-Facilitated Anaerobic Digestion: Evidence for Direct Interspecies Electron Transfer Mediated through Surface Oxygen-Containing Functional Groups.

Acceleration of the anaerobic digestion (AD) process is crucial to achieving energy-efficient recycling of organic wastes. Hydrochar is produced by hydrothermal liquefaction of biomass, yet its application in the AD process is rarely reported. The present study showed that sewage sludge-derived hydrochar (SH) enhanced the methane production rate of glucose by 37%. SH increased the methane production rate from acetate but did not affect acidification and the methane production rate from H2/CO2. SH enhanced hydrogenotrophic methanogenesis, which could be due to direct interspecies electron transfer (DIET) by converting H+, e-, and CO2 to methane. Trichococcus and Methanosaeta were dominant in the AD process with SH. Label-free proteomic analysis showed Methanosaeta was involved in DIET as reflected by the up-regulation of proteins involved in hydrogenotrophic methanogenesis. Hydrochars derived from corn straw (CH), Enteromorpha algae (EH), and poplar wood (PH), as well as activated carbon (AC), were also tested in the AD process. SH, CH, and EH obviously increased the methane production rates, which were 39%, 15%, and 20% higher than the control experiment, respectively. It was neither electrical conductivity nor the total redox property of hydrochars and AC but the abundances of surface oxygen-containing functional groups that correlated to the methane production rates.

Microbial insights of enhanced anaerobic conversion of syngas into volatile fatty acids by co-fermentation with carbohydrate-rich synthetic wastewater.

BACKGROUND: The co-fermentation of syngas (mainly CO, H2 and CO2) and different concentrations of carbohydrate/protein synthetic wastewater to produce volatile fatty acids (VFAs) was conducted in the present study. RESULTS: It was found that co-fermentation of syngas with carbohydrate-rich synthetic wastewater could enhance the conversion efficiency of syngas and the most efficient conversion of syngas was obtained by co-fermentation of syngas with 5 g/L glucose, which resulted in 25% and 43% increased conversion efficiencies of CO and H2, compared to syngas alone. The protein-rich synthetic wastewater as co-substrate, however, had inhibition on syngas conversion due to the presence of high concentration of NH4 +-N (> 900 mg/L) produced from protein degradation. qPCR analysis found higher concentration of acetogens, which could use CO and H2, was present in syngas and glucose co-fermentation system, compared to glucose solo-fermentation or syngas solo-fermentation. In addition, the known acetogen Clostridium formicoaceticum, which could utilize both carbohydrate and CO/H2 was enriched in syngas solo-fermentation and syngas with glucose co-fermentation. In addition, butyrate was detected in syngas and glucose co-fermentation system, compared to glucose solo-fermentation. The detected n-butyrate could be converted from acetate and lactate/ethanol which produced from glucose in syngas and glucose co-fermentation system supported by label-free quantitative proteomic analysis. CONCLUSIONS: These results demonstrated that the co-fermentation with syngas and carbohydrate-rich wastewater could be a promising technology to increase the conversion of syngas to VFAs. In addition, the syngas and glucose co-fermentation system could change the degradation pathway of glucose in co-fermentation and produce fatty acids with longer carbon chain supported by microbial community and label-free quantitative proteomic analysis. The above results are innovative and lead to achieve effective conversion of syngas into VFAs/longer chain fatty acids, which would for sure have a great interest for the scientific and engineering community. Furthermore, the present study also used the combination of high-throughput sequencing of 16S rRNA genes, qPCR analysis and label-free quantitative proteomic analysis to provide deep insights of the co-fermentation process from the taxonomic and proteomic aspects, which should be applied for future studies relating with anaerobic fermentation.

Biogas production from palm oil mill effluent and empty fruit bunches by coupled liquid and solid-state anaerobic digestion.

Biogas production of palm oil mill effluent (POME) and empty fruit bunches (EFB) was performed by coupled liquid (L-AD) and solid-state (SS-AD) anaerobic digestion processes. POME was fed to L-AD digester, while mixed of effluent from L-AD and EFB was fed to SS-AD digester. The maximum overall methane production of 60.9 m3-CH4·ton-1 waste was obtained at an optimal hydraulic retention time of 30 days and an organic loading rate of 1.66 gVS·L-1-reactor·d-1 for L-AD and 6.03 gVS·L-1-reactor·d-1 for SS-AD with L-AD effluent recycling rate of 16.7 mL·L-1-reactor·d-1. The bacterial community in the L-AD reactor was different from the SS-AD reactor, while the archaeal community was similar in both reactors. Synergistaceae, Caldicoprobacteraceae and Lachnospiraceae were increased in the SS-AD reactor. Coupling L-AD and SS-AD is able to increase energy production by 29% and 71% compared to the L-AD and SS-AD alone, respectively, with no outsource SS-AD inoculum required.

Mesophilic and thermophilic anaerobic digestion of aqueous phase generated from hydrothermal liquefaction of cornstalk: Molecular and metabolic insights.

The critical challenge of hydrothermal liquefaction (HTL) for bio-oil production from biomass is the production of large amounts of aqueous products (HTL-AP) with high organic contents. The present study investigated the anaerobic digestion (AD) performances of HTL-AP under both thermophilic and mesophilic conditions, and molecular and metabolic analysis were conducted to provide insights into the different performances. The results showed that thermophilic AD had lower COD removal efficiency compared to mesophilic AD (45.0% vs. 61.6%). Liquid chromatography coupled with organic carbon detection and organic nitrogen (LC-OCD-OND) analysis showed that both high molecular weight (HMW) and low molecular weight (LMW) compounds were degraded to some extent and more LMW acids (LMWA) and recalcitrant aromatic compounds were degraded in the mesophilic reactor, which was the main reason of higher COD removal efficiency. Phenyl compounds (e.g. phenol and 2 methoxyphenol), furans and pyrazines were the recalcitrant chemicals detected through GC-MS analysis. Fourier transform ion cyclone resonance mass spectrometry (FT-ICR-MS) analysis demonstrated the complexity of HTL-AP and the proportions of phenolic or condensed aromatic compounds increased especially in the thermophilic effluents. Metabolites analysis showed that the reasons contributing to the differences of mesophilic and thermophilic AD were not only related to the degradation of organic compounds (e.g. benzoate degradation via CoA ligation) in HTL-AP but also related to the microbial autogenesis (e.g. fatty acid biosynthesis) as well as the environmental information processing. In addition, the enrichment of Mesotoga, responsible for the high degradation efficiency of LMWA, and Pelolinea, involved in the degradation of phenyl compounds, were found in mesophilic reactor, which was consistent with higher removal of corresponding organics.

Molecular and microbial insights towards understanding the anaerobic digestion of the wastewater from hydrothermal liquefaction of sewage sludge facilitated by granular activated carbon (GAC).

Hydrothermal liquefaction of sewage sludge to produce bio-oil and hydro-char unavoidably results in the production of high-strength organic wastewater (HTLWW). However, anaerobic digestion (AD) of HTLWW generally has low conversion efficiency due to the presence of complex and refractory organics. The present study showed that granular activated carbon (GAC) promoted the AD of HTLWW in continuous experiments, resulting in the higher methane yield (259 mL/g COD) compared to control experiment (202 mL/g COD). It was found that GAC increased the activities of both aceticlastic and hydrogenotrophic methanogens. The molecular transformation of organics in HTLWW was further analyzed. It was shown GAC promoted the degradation of soluble microbial by-products, fulvic- and humic-like substances as revealed by 3-dimensional fluorescence excitation-emission matrix (3D-EEM) analysis. Gas chromatography mass spectrometry (GC-MS) analysis showed that GAC resulted in the higher degradation of N-heterocyclic compounds, acids and aromatic compounds and less production of new organic species. Fourier transform ion cyclotron resonance mass spectrometry (FT-ICR-MS) analysis also showed that GAC promoted the degradation of nitrogenous organics. In addition, it was shown that GAC improved the removal of less oxidized, higher nitrogen content, and higher double bond equivalent (DBE) organic compounds. Microbial analysis showed that GAC not only increased the microbial concentration, but also enriched more syntrophic bacteria (e.g., Syntrophorhabdus and Synergistes), which were capable of degrading a wide range of different organics including nitrogenous and aromatic organics. Furthermore, profound effects on the methanogens and the enrichment of Methanothrix instead of Methanosarcina were observed. Overall, the present study revealed the molecular transformation and microbial mechanism in the AD of HTLWW with the presence of GAC.

Thermotolerant cellulolytic Clostridiaceae and Lachnospiraceae rich consortium enhanced biogas production from oil palm empty fruit bunches by solid-state anaerobic digestion.

Thermotolerant cellulolytic consortium for improvement biogas production from oil palm empty fruit bunches (EFB) by prehydrolysis and bioaugmentation strategies was investigated via solid-state anaerobic digestion (SS-AD). The prehydrolysis EFB with Clostridiaceae and Lachnospiraceae rich consortium have maximum methane yield of 252 and 349 ml CH4 g-1 VS with total EFB degradation efficiency of 62% and 86%, respectively. Clostridiaceae and Lachnospiraceae rich consortium augmentation in biogas reactor have maximum methane yield of 217 and 85.2 ml CH4 g-1 VS with degradation efficiency of 42% and 16%, respectively. The best improvement of biogas production was achieved by prehydrolysis EFB with Lachnospiraceae rich consortium with maximum methane production of 113 m3 CH4 tonne-1 EFB. While, Clostridiaceae rich consortium was suitable for augmentation in biogas reactor with maximum methane production of 70.6 m3 CH4 tonne-1 EFB. Application of thermotolerant cellulolytic consortium into the SS-AD systems could enhance biogas production of 3-11 times.

Indigenous Halomonas spp., the Potential Nitrifying Bacteria for Saline Ammonium Waste Water Treatment.

BACKGROUND AND OBJECTIVE: Toxic nitrogen compounds are one cause decreasing of shrimp production and water pollution. Indigenous Halomonas spp., isolated from Pacific white shrimp farm are benefitted for saline ammonium waste water treatment. This study aimed to isolate the heterotrophic-halophilic Halomonas spp. and investigate their ammonium removal efficiency. MATERIALS AND METHODS: Halomonas spp., were isolated by culturing of samples collected from shrimp farm into modified Pep-Beef-AOM medium. Ammonium converting ability was tested and monitored by nitrite reagent. Ammonium removal efficiency was measured by the standard colorimetric method. Identification and classification of Halomonas spp., were studied by morphological, physiological and biochemical characteristics as well as molecular information. RESULTS: There were 5 strains of heterotrophic-halophilic nitrifying bacteria including SKNB2, SKNB4, SKNB17, SKNB20 and SKNB22 were isolated. The identification result based on 16S rRNA sequence analysis indicated that all 5 strains were Halomonas spp., with sequence similarity values of 91-99 %. Ammonium removal efficiency of all strains showed a range of 23-71%. The production of nitrite was low detected of 0.01-0.15 mg-N L-1, while the amount of nitrate was almost undetectable. CONCLUSION: This might suggest that the indigenous Halomonas spp., as nitrifying bacteria involved biological nitrification process for decreasing and transforming of ammonia. Due to being heterotrophic, halophilic and ammonium removing bacteria, these Halomonas spp., could be developed for use in treatment of saline ammonium waste water.

Effects of volatile fatty acids in biohydrogen effluent on biohythane production from palm oil mill effluent under thermophilic condition

Background: Biohydrogen effluent contains a high concentration of volatile fatty acid (VFA) mainly as butyric, acetic, lactic and propionic acids. The presence of various VFAs (mixture VFAs) and their cooperative effects on two-stage biohythane production need to be further studied. The effect of VFA concentrations in biohydrogen effluent of palm oil mill effluent (POME) on methane yield in methane stage of biohythane production was investigated. Results: The methane yield obtained in low VFA loading (0.9 and 1.8 g/L) was 15­20% times greater than that of high VFA loading (3.6 and 4.7 g/L). Butyric acid at high concentrations (8 g/L) has the individual significantly negative effect the methane production process (P b 0.05). Lactic, acetic and butyric acid mixed with propionic acid at a concentration higher than 0.5 g/L has an interaction significantly negative effect on the methanogenesis process (P b 0.05). Inhibition condition had a negative effect on both bacteria and archaea with inhibited on Geobacillus sp., Thermoanaerobacterium thermosaccharolyticum, Methanoculleus thermophilus and Methanothermobacter delfuvii resulting in low methane yield. Conclusion: Preventing the high concentration of butyric acid, and propionic acid in the hydrogenic effluent could enhance methane production in two-stage anaerobic digestion for biohythane production.

Draft genome sequence of Thermoanaerobacterium sp. strain PSU-2 isolated from thermophilic hydrogen producing reactor.

Thermoanaerobacterium sp. strain PSU-2 was isolated from thermophilic hydrogen producing reactor and subjected to draft genome sequencing on 454 pyrosequencing and annotated on RAST. The draft genome sequence of strain PSU-2 contains 2,552,497 bases with an estimated G + C content of 35.2%, 2555 CDS, 8 rRNAs and 57 tRNAs. The strain had a number of genes responsible for carbohydrates metabolic, amino acids and derivatives, and protein metabolism of 17.7%, 14.39% and 9.81%, respectively. Strain PSU-2 also had gene responsible for hydrogen biosynthesis as well as the genes related to Ni-Fe hydrogenase. Comparative genomic analysis indicates strain PSU-2 shares about 94% genome sequence similarity with Thermoanaerobacterium xylanolyticum LX-11. The nucleotide sequence of this draft genome was deposited into DDBJ/ENA/GenBank under the accession MSQD00000000.

Optimization and microbial community analysis for production of biogas from solid waste residues of palm oil mill industry by solid-state anaerobic digestion.

This study investigated the improvement of biogas production from solid-state anaerobic digestion (SS-AD) of oil palm biomass by optimizing of total solids (TS) contents, feedstock to inoculum (F:I) ratios and carbon to nitrogen (C:N) ratios. Highest methane yield from EFB, OPF and OPT of 358, 280 and 324m(3)CH4ton(-1)VS, respectively, was achieved at TS content of 16%, C:N ratio of 30:1 and F:I ratio of 2:1. The main contribution to methane from biomass was the degradation of cellulose and hemicellulose. The highest methane production of 72m(3)CH4ton(-1) biomass was achieved from EFB. Bacteria community structure in SS-AD process of oil palm biomass was dominated by Ruminococcus sp. and Clostridium sp., while archaea community was dominated by Methanoculleus sp. Oil palm biomass has great potential for methane production via SS-AD.